Half-Million-Mile VW

Most people can’t believe it when Randy Melvin tells them his 2000 Volkswagen Beetle has 500,000 miles (804,700 km) on...

September 15, 2020

Most people can’t believe it when Randy Melvin tells them his 2000 Volkswagen Beetle has 500,000 miles (804,700 km) on it. The UPS tractor-trailer driver from Troutman, N.C., commutes 125 miles (201 km) round trip between home and Winston-Salem, N.C., each day. When it came time to purchase a new vehicle back in 1999, he opted for a VW TDI thanks to its high estimated fuel economy, despite the car’s poor reviews.

“If you go back to the Consumer Reports reviews on that 2000 Beetle, they’re terrible,” said Melvin. “My dad said, ‘Why are you getting that? The reviews are so bad.’” But Melvin knew a Volkswagen mechanic nearby whom he trusted and he wanted the fuel-economy benefits of a diesel.

“At the time, the Volkswagen TDI was hard to get a hold of; you had to be in the right place at the right time,” said Melvin. After 20 years, the 1.9L turbodiesel five-speed manual still gets 46 mpg.


AMSOIL exclusively almost since day one

After buying the car, the dealership performed the first three oil changes using Castrol.* Then Melvin switched to AMSOIL synthetic diesel oil exclusively and today uses Signature Series 5W-30 Max-Duty Synthetic Diesel Oil.

A shop mechanic and AMSOIL Preferred Customer with whom Melvin worked piqued his interest in AMSOIL products after sharing a testimonial about a truck driver who’d eclipsed 1 million miles using AMSOIL products.

The car has run excellent all these years. Melvin hasn’t performed any engine maintenance, except replacing the alternator, air compressor and routine timing-chain service.

“It’s proven to me, especially if you can get a half-million miles with no engine failure whatsoever. The thing runs just as powerfully as it ever did.” Melvin used to have a pre-owned 2001 Volkswagen with the same 1.9L diesel engine. “It only had 192,000 miles (309,000 km), but my 2000 would have run circles around it.”

People can’t believe it

How do people react to his story? “They just can’t believe [the car] has a half a million miles on it,” said Melvin. “Because I’ve worked at night the entire 20 years I’ve owned the car, it sits in the garage mainly in the daytime, so it pretty much looks like a brand-new car.

“I change oil every 10,000 miles (16,000 km), and with conventional oil changing every 3,000 (4,800 km), you’re going to spend more money, not counting the labor. To me, it’s a no-brainer.”

Drive it until it quits

“I’ve always believed you should drive a car until it quits,” said Melvin. “To me, buying a car every two to three years isn’t beneficial.” With the help of AMSOIL products, it may be a while before Melvin’s Beetle ever quits running. “I just think it’s a good product. It’s proven to me, and I can tell that to anybody,” he said. “I’ll probably work until I’m 62, so I hope to put at least another 150,000 miles (241,000 km) on it.”

*All trademarked names are the property of their respective owners and may be registered marks in some countries. No affiliation or endorsement claim, express or implied, is made by their use. All products advertised here are developed by AMSOIL for use in the applications shown. 

More like this